Brother HL-1260 User Manual Page 248
- Page / 483
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
USER’S GUIDE
2–10
7.Close the top cover of the printer.
When the cartridge has almost run out of toner, the display shows the
following operator call message to prompt you to replace the toner
cartridge.
16 TONER EMPTY
Although you can print several pages after the toner empty message
appears, be sure to replace the toner cartridge with a new one before it
becomes completely empty.
✒ Note
You can select the printer’s operation when the “Toner Empty” message is
displayed with the MODE switch. The printer continues or stops printing.
For further information, see “Toner Low” in Chapter 4.
For toner cartridge replacement, see “Toner Cartridge” in Chapter 6.
- SERVICE MANUAL 1
- 3. SAFETY INFORMATION 12
- 3.3 Additional Information 13
- 9 AC inlet 14
- 4.2 Cross Sectional View 15
- 1.2 Main Drive 18
- Figure 2.3 19
- 2. LASER/SCANNER SYSTEM 20
- 3. IMAGE FORMATION SYSTEM 21
- Surface potential (V) 22
- Voltage (V) 24
- Transfer charging roller 25
- 3.3 Operation 27
- 4.2 Cassette Feed 29
- 2.5 sec2.5 sec 32
- B48K158-3 38
- 2. PAPER FEED DRIVE CIRCUIT 41
- III - 10 42
- 3. DISPLAY CIRCUIT 43
- 4.1 Outline 44
- 4.2 Protection Functions 44
- III - 13 45
- 5.1 Outline 46
- III - 15 47
- III - 16 48
- PRINTER BODY 51
- 1.4 Font Cover Assy 52
- 1.6 Side Cover R 53
- Figure 4.12 55
- Figure 4.14 55
- Figure 4.13 55
- 1.9 Control Panel Unit 56
- 1.12 Paper Feed Chassis Unit 58
- 1.13 Separation Pad Assy 59
- 1.14 MP PE Sub Actuator 60
- 1.15 P Feed /Size-SW PCB Assy 60
- 1.16 Side-Switch Spring 60
- 1.17 Regist sensor actuator 61
- 1.19 PE Sensor Actuator MP 61
- 1.20 Tray Sensor Holder 62
- 1.21 Roller Holder 62
- Figure 4.34 63
- Figure 4.35 63
- Figure 4.36 63
- 1.23 Paper Pick-up Solenoid 64
- 1.24 Paper Feed Motor Assy 64
- 1.25 MP Tray Cover 65
- 1.26 MP Tray Assy 65
- Figure 4.44 66
- Figure 4.43 66
- Figure 4.45 66
- 1.28 Latch 67
- Figure 4.55 69
- Figure 4.53 69
- Figure 4.54 69
- Figure 4.52 69
- 1.30 Transfer Unit 70
- Figure 4.63 72
- Figure 4.62 72
- Figure 4.64 72
- 56T link 74
- 3. LIST OF STANDARD TOOLS 76
- Table 5.3 77
- 1.2 Basic Procedure 79
- 2.1 Test Printing 79
- TEST PRINT 79
- 3. IMAGE DEFECTS 80
- All black 83
- Polka dots 84
- White vertical streaksI-12 86
- Poor fixingI-14 87
- No DC power suppliedM-1 88
- 5.1 Paper Jams 96
- 5.2 Incomplete Paper Feed 99
- 3 4 5 6 7 8 100
- (11) Flash memory check 101
- (12) MIO check 101
- (13) Turn off the power 101
- 6.2 DRAM Test 102
- 7. STATUS MESSAGE LIST 103
- UK2516000 108
- B48K139/140CIR 108
- UK2495000 109
- B48K158/159CIR(1/8) 109
- B48K158/159CIR(2/8) 110
- B48K158/159CIR(3/8) 111
- B48K158/159CIR(4/8) 112
- B48K158/159CIR(5/8) 113
- B48K158/159CIR(6/8) 114
- B48K158/159CIR(7/8) 115
- B48K158/159CIR(8/8) 116
- UK2527000 117
- B48K143CIR 117
- UK2674000 118
- B48K165CIR 118
- CONTENTS 122
- CHAPTER I GENERAL 122
- CHAPTER VI TROUBLESHOOTING 124
- APPENDICES 124
- CHAPTER I GENERAL 125
- Printable area 126
- Z (HL-1660 only)60 HZ 129
- 1. BASIC OPERATIONS 132
- 4. PAPER PICK-UP/FEED SYSTEM 133
- 4.3 MP Tray Feed 134
- 4.4 Paper Jam Detection 135
- 4.9 sec4.9 sec 136
- JamNormal 137
- 9.56 sec 137
- CHAPTER III ELECTRICAL SYSTEM 138
- 1.2 Video Controller Circuit 139
- B48K234 -2 141
- Figure 3.4 Main PCB (HL-1660) 142
- 1.3 Engine Controller Circuit 143
- Figure 3.6 Main PCB Circuit 144
- CHAPTER IV MECHANICAL SYSTEM 145
- 1.2 Toner Cartridge Lid 146
- 1.7 DC Fan Motor 146
- 1.8 Main PCB 147
- Figure 4.6 148
- Figure 4.7 148
- 1.10 Scanner Unit 149
- 1.11 Cartridge Stopper Assy 149
- 1.31 DC Gear Holder Assy 150
- 1.36 Paper Tray 151
- Table 5.1 152
- CHAPTER VI TROUBLESHOOTING 153
- Malfunction of buzzerM-5 154
- CODE UK3268000 168
- B48K259/235CIR(1/7) 168
- B48K259/235CIR (2/7) 169
- B48K259/235CIR(3/7) 170
- B48K259/235CIR (4/7) 171
- B48K259/235CIR(5/7) 172
- B48K259/235CIR (6/7) 173
- B48K259/235CIR(7/7) 174
- CODE UK3253000 175
- B48K253CIR(1/1) 175
- 13 . PAPER FEEDER 176
- 12 . PAPER FEEDER 178
- T/I No. PR98202 / PR99087 180
- 9 . PAPER FEEDER 182
- TI NO. PR99087 182
- MODEL HL-2060 54T-U04-630 183
- 1 . FEEDER UNIT 184
- TI NO. 97-P049 / PR99087 184
- LT-2000 54T -X01-630 186
- MODEL LT-2000 54T-X01-630 187
- PARTS REFERENCE LIST 188
- B48K056 - 201 A 189
- 2 . PAPER FEEDER PCB 191
- 3 . CONTROL PANEL 193
- 4 . PCB ATTACHMENTS 193
- 5 . MAIN PCB, OTHERS 195
- HL-1260e 196
- 6 . MAIN PCB, ISRAEL 197
- HL-1260e 54T-U01-104 198
- 7 . HIGH-VOLTAGE POWER SUPPLY 199
- 8 . LOW-VOLTAGE POWER SUPPLY 199
- TI No.96-P033 199
- 9 . COVERS 201
- 10 . CHASSIS 201
- 11 . TRANSFER 203
- 12 . PAPER TRAY 203
- 15 . FIXING UNIT,120V/230V 207
- 14 . SCANNER 207
- 16 . DOCUMENTS 209
- 17 . PACKING MATERIALS 209
- 19 . ADJUSTING TOOL KIT 211
- 18 . OPTIONAL PARTS SET 211
- HL-1260e 213
- /HL-1660 213
- HL-1260e/HL-1660 215
- Warning 216
- TABLE OF CONTENTS 217
- USER’S GUIDE 218
- (For U.S.A. only) 223
- REGULATIONS 225
- For Your Safety 226
- CHAPTER 1 229
- CHAPTER 1 GENERAL 231
- ABOUT THIS PRINTER 232
- CHAPTER 2 239
- GETTING STARTED 239
- Toner Cartridge 240
- General View 241
- SETTING UP THE PRINTER 243
- Removing the Protective Parts 244
- 14 NO CARTRIDGE 245
- CHAPTER 2 GETTING STARTED 247
- 16 TONER EMPTY 248
- 04 SELF TEST 258
- LJ READY 001P T1 258
- PRINT FONTS C 260
- PRINT FONTS P 260
- 6. Press the SET switch 261
- CHAPTER 3 263
- AUTOMATIC EMULATION SELECTION 265
- AUTOMATIC INTERFACE SELECTION 267
- ABOUT THE CONTROL PANEL 269
- Using the Panel Switches 271
- Printer Settings 272
- PAPER HANDLING 273
- Cassette Feed 277
- LOAD PAPER ↔**** SIZE 277
- Manual Feed 278
- Face Down Print Delivery 279
- Face Up Print Delivery 279
- CHAPTER 4 280
- CONTROL PANEL 280
- 01 PRINT 002 L 282
- SWITCHES IN NORMAL MODE 284
- SET Switch 285
- ▲▲ (UP) or ▼▼ (DOWN) Switch 285
- CHAPTER 4 CONTROL PANEL 286
- INTERFACE MODE 294
- I/F=PARALLEL 297
- FORMAT MODE 299
- ORI=PORTRAIT * 299
- ORI=PORTRAIT Portrait 299
- ORI=LANDSCAPE Landscape 299
- • Left margin = column 0 304
- • Right margin = Max. value 304
- • Auto MASK ON 304
- SETTING=PEN1 305
- SIZE 1=3 dots * 305
- GRAY 1=100% * 305
- STANDARD SET 306
- ALTERNATE SET 306
- ANSI ASCII * 306
- PAGE PROTECTION 310
- 31 PRINT OVERRUN 310
- DATA ID=##### 313
- SET KEY --> END 315
- MACRO ID=##### 316
- FONT ID=##### 316
- PASS NO=*** 321
- INCORRECT!! 321
- PAGE COUNTER 327
- COUNT= 861 327
- EXIT MODE 327
- FONT Switch 328
- exit Exit 328
- PITCH= 10.00 * 332
- PITCH= 16.66 332
- SYMBOL SET p 332
- ROMAN 8 p* 332
- INTERNAL FONT * 334
- CHARACTER SET 336
- US ASCII * 337
- TABLE PRINT 337
- 01 PRINT 001P T1 340
- 07 FF PAUSE 340
- No Data !!! 340
- CONTINUE Switch 342
- SWITCHES IN SHIFT MODE 343
- TIME OUT= 5s * 345
- EPSON/IBM=EPSON* 345
- KEEP PCL=OFF 345
- FEEDER=AUTO * 350
- FEEDER=AUTO Auto paper feed 350
- AUTO=T1>MP * 351
- MP FIRST=OFF * 351
- MANUAL FEED=OFF* 352
- MP SIZE=LETTER * 352
- PAPER IN=CONT * 353
- MEDIA TYPE 353
- REGULAR * 354
- DUPLEX MODE 354
- DUPLEX=OFF * 354
- BIND=LONG * 354
- 06 DEMO PAGE 365
- 05 TEST PRINT 365
- 06 PRINT CONFIG 365
- 06 PRINT FONTS I 366
- HEX DUMP MODE 367
- CHAPTER 5 369
- CHAPTER 5 OPTIONS 371
- Selecting the Optional Fonts 372
- MODULAR I/O CARD 374
- RAM EXPANSION 375
- DUPLEX UNIT (DX-1200/DX-1600) 379
- CHAPTER 6 381
- MAINTENANCE 381
- CHAPTER 6 MAINTENANCE 383
- Cleaning 385
- • Never touch the hot fuser 386
- CHAPTER 7 388
- TROUBLE SHOOTING 388
- CHAPTER 7 TROUBLESHOOTING 390
- Possible Problems 393
- 13 JAM XXXXXX 393
- 13 JAM REAR 394
- 13 JAM INSIDE 397
- 13 JAM TRAYS 398
- Functions 408
- Electrical and Mechanical 409
- PAPER SPECIFICATIONS 410
- Appendix–5 411
- Appendix–6 412
- Appendix–7 413
- INTERFACE SPECIFICATIONS 414
- Appendix–9 415
- Appendix–10 416
- RS-232C Serial Interface 417
- Appendix–12 418
- Appendix–13 419
- SYMBOL/CHARACTER SETS 420
- HP LaserJet 4+ Mode 421
- PC-8 (10U) 422
- PC-8 D/N (11U) 422
- PC-850 (12U) 422
- PC-852 (17U) 422
- PC-8 Turkish (9T) 423
- Windows Latin1 (19U) 423
- Windows Latin2 (9E) 423
- Windows Latin5 (5T) 423
- Legal (1U) 424
- Ventura Math (6M) 424
- Ventura Intl (13J) 424
- Ventura US (14J) 424
- PS Math (5M) 425
- PS Text (10J) 425
- Math-8 (8M) 425
- Pi Font (15U) 425
- MS Publishing (6J) 426
- Windows 3.0 (9U) 426
- Desktop (7J) 426
- MC Text (12J) 426
- Appendix–21 427
- EPSON Mode 428
- PC-8 D/N 429
- PC-8 Turkish 430
- IBM Mode 431
- Appendix–27 433
- HP-GL Mode 433
- ANSI ASCII 433
- 9825 CHR. SET 433
- FRENCH/GERMAN 434
- SCANDINAVIAN 434
- SPANISH/LATIN 434
- JIS ASCII 434
- ROMAN8 EXT 435
- ISO SWEDISH 435
- ISO SWEDISH:N 435
- ISO NORWAY 1 436
- ISO GERMAN 436
- ISO FRENCH 436
- ISO U.K 436
- ISO ITALIAN 437
- ISO SPANISH 437
- ISO PORTUGUESE 437
- ISO NORWAY 2 437
- Typefaces 438
- Appendix–33 439
- Appendix–34 440
- Appendix–35 441
- QUICK REFERENCE OF COMMANDS 442
- Appendix–37 443
- Appendix–38 444
- ESC * c 130 P 445
- Appendix–40 446
- Appendix–41 447
- Appendix–42 448
- Appendix–43 449
- Appendix–44 450
- Appendix–45 451
- Appendix–46 452
- Appendix–47 453
- Appendix–48 454
- Header 94 bytes 455
- File length 455
- Picture = #### 455
- Picture Data length 455
- Appendix–50 456
- Appendix–51 457
- Appendix–52 458
- Appendix–53 459
- Appendix–54 460
- HP-GL/2 Command Sets 461
- Appendix–56 462
- Appendix–57 463
- EPSON FX-850 Mode 464
- Appendix–59 465
- Appendix–60 466
- IBM Proprinter XL Mode 467
- Appendix–62 468
- Appendix–63 469
- Appendix–65 471
- Bar Code Control 472
- ~ 32767) 473
- Appendix–69 475
- Appendix–70 476
- Appendix–71 477
- Appendix–72 478
- Appendix–73 479
Related products and manuals for Printers Brother HL-1260
Printers Brother HL-5240L User Manual
(34 pages)
(34 pages)
Printers Brother HL-1070 User Manual
(93 pages)
(93 pages)
Printers Brother MFC 1970MC User Manual
(136 pages)
(136 pages)
Printers Brother HL-2070N EN User Manual
(109 pages)
(109 pages)
Printers Brother TD4100N User Manual
(80 pages)
(80 pages)
Printers Brother HL 4040CN User Manual
(177 pages)
(177 pages)
Printers Brother MFC 9880 User Manual
(31 pages)
(31 pages)
Printers Brother MFC 9560CDW User Manual
(199 pages)
(199 pages)
Printers Brother HL 4150CDN User Manual
(2 pages)
(2 pages)
Printers Brother DCP-110C User Manual
(212 pages)
(212 pages)
Printers Brother 4800 User Manual
(174 pages)
(174 pages)
Printers Brother DCP9040CN User Manual
(158 pages)
(158 pages)
Printers Brother HL 1660 User Manual
(4 pages)
(4 pages)
Printers Brother 8910DW User Manual
(31 pages)
(31 pages)
Printers Brother DCP 8065DN User Manual
(112 pages)
(112 pages)
(40 pages)
Printers Brother DCP-560CN User Manual
(118 pages)
(118 pages)
Printers Brother HL-1450 User Manual
(2 pages)
(2 pages)
© 2020, manymanuals.com. All rights reserved. | 0.091 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals